Tell us about the job
Takes about a minute. No obligation.
A contractor quoting a furnace installation in Union County has to account for what the local climate demands before choosing equipment, because sizing is a local question. 82 severe weather events were recorded in Union County, Kentucky between 2015 and 2024. At that rate, severe weather is a standing condition of operating here, and a furnace sized to catalog averages will be working harder than its rating assumes across every cold stretch that follows a weather event. A contractor who gets the load calculation right upfront saves the homeowner a second visit to correct a unit that short-cycles or runs continuously through a hard winter.
Ductwork laid down for an older heating system carries assumptions about static pressure, trunk sizing, and return air that a modern furnace may not share. Half the homes in Union County, Kentucky were built in 1976 or earlier (2020-2024 ACS 5-year). When a contractor scopes a furnace installation here, the duct system gets measured and evaluated before anything else is priced, because mismatched airflow causes comfort problems and efficiency loss that no equipment upgrade corrects on its own. The electrical service gets the same look, since a newer furnace with variable-speed components draws differently than what the original wiring was planned around.
What Gets Installed With a New Furnace
The furnace itself sits in a mechanical room, basement, or utility closet and is the unit that produces heat for the house. A burner assembly inside it ignites the fuel, and a heat exchanger transfers that warmth to the air before it moves into the home. A contractor sets the furnace in place and connects it to the gas line and the existing duct openings.
The flue pipe runs from the furnace up and out of the house, carrying combustion gases away from the living space. Beside or near the furnace, a contractor installs the air handler or blower cabinet if the home needs one, along with a new thermostat on an interior wall to give the homeowner control over the system.
The drawing shows a typical layout, and a licensed contractor determines exactly what applies to this house.
Get matched in Union CountyUnion County, Kentucky, by the numbers
82 severe weather events were recorded in Union County, Kentucky between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Union County, Kentucky were built in 1976 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesUnion County, Kentucky holds 5,846 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 70.2% of the occupied homes in Union County, Kentucky (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCodes & Standards for Furnace Work in Union County, Kentucky5 sourced rules and standards
What Happens Once a Contractor Comes Out
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing Rules for Union County, Kentucky
Kentucky requires a licence to practise heating, ventilation and air conditioning contracting: a person may not do the work unless they have met the state licensing requirements.
Severe Weather Events in Union County
Local weather puts real demands on heating equipment, and those demands shape what a furnace needs to handle year after year. What gets installed here has to be sized and built for this county's conditions, which is why the regional weather record is part of the picture.
82 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.